Product ID:ANTI-SEIZE & LUBRICANT COMPOUND, S00620
MSDS Date:08/17/1998
FSC:8030
NIIN:00N091672
Status Code:A
MSDS Number: CJNZW

SHERWIN-WILLIAMS CO, KRYLON/SPRAYON INDUSTRIAL PRODUCTS

31500 SOLON ROAD
SOLON, OH 44139
US

Emergency Phone: 216-566-2917

Info Phone: 800-777-2956

Cage: 09800

SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.

BEDFORD HEIGHTS, OH 44146 US

Telephone: 216-292-7400 OR 216-595-8634

Cage: 09800

760.0

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1800 MG/M3;1000 PPM

760.0

CAS: 106-97-8

RTECS: EJ4200000

ACGIH TLV: 1900 MG/M3;800 PPM

50.0

CAS: 142-82-5

RTECS: MI7700000

OSHA PEL 2000 MG/M3;500 PPM

ACGIH TLV: 1640 MG/M3;400 PPM

GRAPHITE

CAS: 7782-42-5

RTECS: MD9659600

OSHA PEL see Table Z-3

ACGIH TLV: 2 MG/M3

BRONZE PIGMENT

COPPER COMPOUND [% COPPER]

Fraction By Weight: 2 [2%]

ZINC COMPOUND [% ZINC]

Fraction By Weight: 2[0.2%]

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHAL &/SKIN/EYE
CONTACT, DEPENDING ON CONDITIONS OF USE. MINIMIZE EXPOSURE, FOLLOW
RECOMMENDATIONS FOR PROPER USE, VENT, & PERSONAL PROTECTIVE
EQUIPMENT. ACUTE: IRRITATION OF EYE, SKIN & RESPIRATORY SYSTEM.
MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXCESSIVE OVEREXPOSURE MAY
RESULT IN UNCON & POSIBLY DEATH. OVEREXP TO METHYLENE CHLORINE CAN
RAISE LEVEL OF CARBON MONOXIDE IN BLOOD. S IGNS & SYMPTOMS OF
OVEREXPOSURE: HEADACHE, DIZZS, NAUSEA, & LOSS OF COORDINATION ARE
INDICATIONS OF EXCESSIVE EXPOSURE VAPORS/SPRAY MIST. REDNESS &
ITCHING/ BURNING SENSATION MAY INDICATE EYE/EXCESSIV E SKIN EXPOS.
(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: CHRONIC: PROLONGED OVEREXPOSURE TO
SOLVENT INGREDIENTS IN SECTION 2 MAY CAUSE ADVERSE EFFECTS TO
LIVER, URINARY AND CARDIOVASCULAR SYSTEM. REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OVER EXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR PROBLEMS MAY BE
AGGRAVATED BY OVEREXPOSURE TO MATHYLENE CHLORIDE.

First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION.

Flash Point:=-28.9C, -20.F
Lower Limits:1.0%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER MAY
BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP AND
POSSIBLE AUTOIGNI TION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE (DUE TO BUILD-UP
OF PRESS) WHEN EXPOSED TO EXTREME HEAT ISOLATE FROM HEAT,
ELECTRICAL EQUIP, SPARKS & OPEN FLAME. APPLICATION TO HOT SURFACES
REQUIRES SPECIAL PREC. DURING EME RGENCY CNDTNS OVEREXP TO DECOMP
PRODS MAY CAUSE A HLTH HAZ. SYMPTOMS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:CONTENTS ARE EXTREMELY FLAMMABLE. KEEP
AWAY FROM HEAT, SPARKS, & OPEN FLAME. VAPS WILL ACCUMULATE READILY
& MAY IGNITE EXPLOSIVELY.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE: KEEP AREA
VENT-DO NOT SMOKE-EXTING ALL FLAMES, PILOT LIGHTS, & HEATERS-TURN
OFF STOVES, ELECTRIC TOOLS & APPLIANCES, & ANY OTHER SOURCES OF
IGNIT. CONSULT EPA COD E. USE APPRVD BONDING & GROUNDING PROC.
CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCINERATE/EXPOSE TO TEMP
(SUPDAT)

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS IN SECT ION 2.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
SECTION 2 IS MAINTAINED BELOW APPLIC EXPOS LIMITS. REFER TO OSHA
STANDARDS 1919.94,1910.107, 1910.108.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMCIAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGH SHOWER .
Work Hygienic Practices:WEAR GLOVES RECOMMENDED BY GLOVE SUPPLIER FOR
PROT AGAINST MATL IN SEC 2.
Supplemental Safety and Health
OTHER PREC: ABOVE 120F. HEAT FROM SUNLIGHT, RADIATORS, STOVES, HOT
WATER, AND OTHER HEAT SOURCES COULD CAUSE CONTAINER TO BURST. DO
NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS CAN
BE HARMFUL OR FATAL.

Boiling Pt:<93.9C, 201.F
B.P. Text:0-201F
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Pres:SEE INGRIDENTS
Vapor Density:HVR/AIR
Spec Gravity:0.66-0.99
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:N.A.

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS LISTED IN SECTION 2.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZARDOUS AS
DEFINE UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) 40
CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE THE
APPLICABLE EPA HAZARDOUS WASTE NUMBERS. DO NOT INCINERATE.
DEPRESSURIZE CONTAINER. DISPOSE I/A/ W/FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THESE PRODUCTS ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THE
FOLLOWING PRODUCTS CONTAIN CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, AND BIRTH DEFECTS AND OTHER
REPRODUCTIVE HARM; S00607, S00620, S00700, S0 0710, 1324. WARNING:
THE FOLLOWING PRODUCTS CONTAIN CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: S00615.